Dual Heater Upgrade Kit

Key Features Installs in minutes Includes 750 Watt Coil Heater Copper Washer Heater Coil Extension Wire About This Product Add the Banks 750 Watt Heater Upgrade Kit to your Monster-Ram® for cold-weather starts as low as -30°F/-34°C with block heat and -20°F/-29°C without block heat. Built To Survive This simple bolt-on kit requires no maintenance. Unlike the factory Cummins grid heater, which can fail and destroy your engine, Banks coil heaters are designed to fail safely, avoiding catastrophic engine damage. How It Works Doubles your Banks Monster-Ram®'s heat output from 750 watts to 1500 watts. Cold Weather Starting Recommendations The Banks Dual-Heat Upgrade Kit is designed around RAM’s block heating recommendations. RAM recommends the use of a block heater at 0°F/-17°C and mandates its use at -20°F/-29°C. Failure to follow these instructions could lead to premature wear and/or failure of key components, including pistons, rings, and cylinder walls. We followed RAM's cold start recommendations. Per the owner’s manual, RAM recommends the use of the block heater when the temperature drops below 0°F/-17°C and mandates the block heater at temperatures below -20°F/-29°C. Using a controlled climate chamber, our first test utilized block heat and two Banks coil heaters (1500 watts total). The Monster-Ram® enabled our test truck to cold start down to -30°F/-34°C. Against RAM’s recommendations, we also attempted to cold start with the same two coil heaters and no block heat. We were able to cold start down to -20°F/-29°C. Adding a third coil heater (2,250 watts total), the truck started at -30°F/-34°C.* All tests were performed with two intake air pre-heat cycles per the owner’s manual. Intake air temperature is just one factor contributing to a successful cold start. Individual results may vary depending on your vehicle’s age and overall condition. Testing is ongoing with a detailed video forthcoming. *Battery boosting may be required for sufficient cranking RPM. Test Vehicle Configuration 2024 Ram 2500 4x4 Tradesman, dual cab short bed Mileage 7,8XX Vehicle unmodified apart from Monster-Ram® Minimum 12-hour cold soak at specified temperature #1 Diesel fuel AMSOIL Signature Series 5W40 motor oil New Interstate AGM batteries with full state of charge New MOPAR fuel filter New MOPAR fuel/water separator New MOPAR air filter