1990-2000 Lexus LS 400 Front Air Suspension Conversion Kit (TC1FB)

Convert Your Electric Suspension To A Coil Spring Suspension. End Your Electronic Suspension Problems Forever... Strutmasters 1990-2000 Lexus LS400 Front Air Strut To Coil Spring Strut Conversion Kit is the perfect solution to your air suspension problems. Designed to be very affordable, you can convert your air suspension to use standard shocks/struts and coil springs for less than the price of replacing one air strut. Conversion Kit Features Saves Money All New Components Returns Front Suspension To Factory Ride Height More Reliable Than Air Suspensions No Modifications Required To Install Easy To Install Premium Springs Air Suspension Conversion Kit Includes 2 Complete Front Strut Assemblies With New Mounts, Hardware And Springs All Necessary Hardware Detailed Instructions This Conversion Kit Fits 1990 Lexus LS400, 1991 Lexus LS400, 1992 Lexus LS400, 1993 Lexus LS400, 1994 Lexus LS400, 1995 Lexus LS400, 1996 Lexus LS400, 1997 Lexus LS400, 1998 Lexus LS400, 1999 Lexus LS400, 2000 Lexus LS400 Product Notes If The Front Suspension Has Failed, The Rear Struts Are the Same Age, And The Leaking Front Suspension Has Damaged The Compressor, and the Rear Isn't Far Behind. Save Time, And Save Money By Ordering The 4 Wheel Kit Replaced Components The 1990-2000 Lexus LS 400 is built with the following suspension components: 1990-2000 Lexus LS 400 Air Struts (x4)- struts that contain an air bladder whose dampening capabilities is controlled by the suspension control module; these have two functions. They connect the wheel of a vehicle to the driving surface in order to reduce the effects of vertical travel on a rough surface which controls the bounciness, and therefore comfort, of a vehicle. They also help maintain the vehicles correct ride height, especially whenever the amount of load put onto the vehicle changes. 1990-2000 Lexus LS 400 Height Sensors (x2)- a linkage located near each wheel of a vehicle with any electronic suspension that, either mechanically or electronically, constantly measures the height of the vehicle, and reports this information back to the control module so that the computer can identify if changes in height need to be adjusted accordingly. The ride height sensor is a moving part, and like all moving parts, they will eventually wear out. 1990-2000 Lexus LS 400 Compressor- This vehicle is equipped with one air suspension compressor. The compressor is responsible for pumping up the air springs and shocks. When the air suspension starts leaking, the compressor is forced to run continuously to try and keep the air springs inflated. After a couple of days of running non-stop, the compressor will burn itself out. Replacing the compressor is a timely and expensive project to undertake. 1990-2000 Lexus LS 400 Dryer Assembly- This vehicle is equipped with a dryer assembly. The dryer assembly is responsible for getting moisture out of the air lines. Once the air suspension parts start to leak, moisture will build up throughout the air system. Moisture damages the air suspension components from the inside out. The dryer must be replaced whenever the compressor is replaced to prevent further damage. 1990-2000 Lexus LS 400 Suspension Control Module- This vehicle is equipped with a suspension control module. This module is the brain of the suspension system and it reads all of the signals that are being sent by the height sensors and determines if the vehicle needs to be raised or lowered. 1990-2000 Lexus LS 400 O-rings- Although they are the least expensive parts of the air suspension, they are responsible for maintaining the seal where all of the air lines connect. Be sure to replace the O-rings when repairing any air suspension system. Suspension Failure Signs An inability of the 1990-2000 Lexus LS 400 to reach and maintain the proper ride height is likely caused by a failed or leaking air suspension system. Early diagnosis of a bad suspension is the key to avoiding total failure. Look for a sudden uneven height difference between different sides of the LS 400. A height variance may look like one sagging end, one inflated end, a “squatting down” appearance, or a shifting lean from side to side. If these imbalances are not fixed the air compressor will wear out. When suspension failure is advanced the suspension warning light will illuminate on the dashboard. The LS 400 owner should have any suspension issue fixed as soon as it's noticed. OEM Replacement Cost '+ Air Strut ($799/strut) + Compressor and Dryer Assembly ($435) = TOTAL: Over $3,630 (and that doesnt even include replacing electronic components that are known to fail such as the height sensors). Why StrutmastersStrutmasters' air to non-air suspension conversion kit saves LS 400 owners time, frustration, and money when the air suspension system goes bad. The kit eliminates the complex electrical components of the air system that must always function in sync. The kit, manufactured in America, comes complete with two front strut assemblies with new mounts, hardware, and springs. It is a direct replacement solution- no modifications are needed before it's installed. Customers appreciate that the kit is installed in as little as one hour per wheel, thanks to accompanying detailed instructions and online installation videos. If further assistance is needed, Strutmasters ASE certified experts are available to offer technical support. The quality parts are so reliable, we guarantee them with a 1-year warranty. If top-notch customer service and quality parts aren't enough, the low price of the kit is what convinces most customers to make the switch from air to non-air suspension using our coilover conversion kit. The kit costs a fraction of the price of dealership direct replacement and individual aftermarket air part replacement. OEM Numbers4801050090, 4801050100, 4801059015, 4801050010, 4801050020, 4801050070, 4801050050, 4801050060, 4801050080